Ebb and Grow buckets converted into 36 site recirculating DWC.

I think it mights have been caused by a burn, or nutrient imbalance in the buckets themselves.
I pulled an all nighter last night observing the plants and watching the nightly "drain" cycle closely.

I had the drain setting on my ebb/gro system set to drain for 30 minutes, pushing all the water from the buckets into my 105gallon rez.
This is what "recirculates" my DWC system, and it only happens once a day during the night cycle.

Keep in mind my Bluelab meter sits permanently in my brain.

Well, 30 minutes of drain only drained half my system, so the water in each bucket is not getting properly mixed ever day.
This means that my meter reading in the brain is not very accurate, and doesn't properly reflect pH or PPM throughout the system.

After changing my "drain" setting to 1 hour, my PPM read 1050, and my pH was unchanged at 5.9.

I think I might have been looking a early stage nute-burn, or a imbalance cause a lockout of cal or mag.

After my foliar feed last night of epsom salts + tap water (my poor man's cal+mag), the problem doesn't seem to have progressed much at all.
I noticed my leaf tips curling down on fan leaves. Pretty sure that is a sure sign of nute-burn/lockout.

I dropped my PPM (.5) to 950 last night while all the water was drained into my 105 gallon rez. I'll monitor closely and add pics daily.

Sounds like you are figuring things out pretty well. The tap water will def help with some micro nutrients. I think you will be just fine through out this grow. Just keep a close eye on everything. STAY HIGH!!!

Day 11

I guess the rez change is my backup option at this point. It's hard to tell if the problem has progressed or not. Especially since I just did my first big bottom trim. Took off about a contractor trash bag worth of green stuff.

Hopefull all is well though. Here are pics from today, including some macro shots a affected leaf.

Day 13

All is well. More supercropping

Day 15
Came in and did more supercropping. Lowered my PPM to 860 after reading about lucas DWC's last a few nights ago. All problems have seemingly vanished. Also read that 2ml/gallon is a safe dose for 30% H202. So I began adding that today. Going to add every 48 hours.

....Should have noted. This is also day 2 of flowering .

Those lids made for 5 gallon buckets?

givememeganja said:

Those lids made for 5 gallon buckets?

Click to expand...

Absolutely

Day 4 flowering. Dropped ppm.

I have 2 ebb and grow systems and I too want to switch to DWC. I wanted to convert my stuff as well but I decided on making one from scratch. I actually wanted to switch to UDWC and I came to the conclusion that I could not convert the ebb and grow units to facilitate the design. I couldn't believe how cheap it was to make. A word of caution for anyone - water temperature is critical. Do not let the water get the same temp as the room or your roots will rot / algae will take over and kill everything. I was going to do what you are doing but I have concluded that I am better off selling the equipment and making a DIY system. Good work though from what I have read so far.

I like the setup, looks very clean. Plants look great, only thing I might suggest is to find something to cover the rockwool cubes. I recently stumbled upon Cube Caps, they make different sizes depending on what you're using and even have a cap that you can incorporate drip lines into. I haven't used them yet but I'll be ordering in the next week, fairly cheap too only $1-$2 a per top. Everything looks great keep up the good work!

SilverIce9 said:

Day 4 flowering. Dropped ppm.

View attachment 2646748View attachment 2646749View attachment 2646750View attachment 2646751View attachment 2646752View attachment 2646753View attachment 2646754

Click to expand...

Beautiful system!
You can bypass that Calcium deficiency by running your PH lower during Veg.
5.5 with a drift to 5.8 keeps it away for me.
I ran 5.8 on the dot on my first couple grows and always had that. (Yielded like MoFo's still)
Once I relaxed, lowered the PH, and let it drift a little my plants were a lot happier.

Tav.

Thanks for all the input guys. I actually found that the "deficiency" was actually just a design flaw in my conversion. Without undercurrent running, you have to ebb/flow more than just once during the night cycle. Once I changed it to flood/drain 5 times during the day cycle, the problem went away the same day and stayed away.

ComputerGroove:
Def cheaper to sell brain bucket system and build from scratch. However, it is less work to convert, and you end up with a unique (though not necessarily better) system. I plan on doing UCRDWC at another location to decide which I like better.

Day 7 Flowering.


Mysterious drop in pH. from 5.7 to 4.5 in 2 days. Water is clear and roots are white. Came out of the blue. Had to add like 500 ml of GH pH up... Unbelievable. Caibrated 2 pH meters. Wouldn't have believed it otherwise. Brought pH back to 6.0 We'll see what happens when I go over there today...

So after adding at least 400-500 ml of pH up, it has stabilized at 6.0 for 36 hours. I'll keep you all posted.

Day 9 Flowering

pH is still dropping, albeit a lot slower. Dropped from 6.0 2 days ago to it's current pH of 5.8.

ppm is pretty steady. Going to err on the low side of lucas formula this grow and keep ppm 800-900. I know this makes it technically not lucas formula, but so be it. Addbacks are now calculated to bring my rez back to between 800-900. I keep seeing "the claw" on some older fan leaves. Nothing very serious, but I''d rather undernute than overnute.

Overall, I would say everything looks stellar though so far in my prototype system.

Bonus PICS!!! This is my other system. ebb/gro 4000watt medi legal. Also Blue Dream.
On day 23 of flowering .

Day 11 Flowering
Pics, ppm steady, ph dropping slowly. Not much to report. Added DM Zone for first time at 1ml/gal.

Day 14 Flowering

Everything is still looking good. Planning on upping my PPM to true Lucas formula levels ([email protected]) in the next couple days.

PH did the same thing it did last week... As follows...
Day 1 - 5.8
Day 2- 5.7
Day 3 - 5.6
Day 4 - 5.4
Day 5 - 4.8

So this is the second time the pH has swung just like that in as many weeks.
I added a ton of pH up today to bring it back to 6.0-ish.
I added more pH up after snapping the picture of my meter.

Any input from others would be greatly appreciated. Thanks!